Exhaust gas

A diesel-powered truck emits an exhaust gas rich in black particulate matter when starting its engine.

Exhaust gas or flue gas is emitted as a result of the combustion of fuels such as natural gas, gasoline, petrol, biodiesel blends,[1] diesel fuel, fuel oil, or coal. According to the type of engine, it is discharged into the atmosphere through an exhaust pipe, flue gas stack, or propelling nozzle. It often disperses downwind in a pattern called an exhaust plume.

It is a major component of motor vehicle emissions (and from stationary internal combustion engines), which can also include:

Motor vehicle emissions contribute to air pollution and are a major ingredient in the creation of smog in some large cities. A 2013 study by MIT indicates that 53,000 early deaths occur per year in the United States alone because of vehicle emissions.[2] According to another study from the same university, traffic fumes alone cause the death of 5,000 people every year just in the United Kingdom.[3]

Composition

The largest part of most combustion gas is nitrogen (N2), water vapor (H2O) (except with pure-carbon fuels), and carbon dioxide (CO2) (except for fuels without carbon); these are not toxic or noxious (although carbon dioxide is a greenhouse gas that contributes to global warming). A relatively small part of combustion gas is undesirable noxious or toxic substances, such as carbon monoxide (CO) from incomplete combustion, hydrocarbons (properly indicated as CxHy, but typically shown simply as "HC" on emissions-test slips) from unburnt fuel, nitrogen oxides (NOx) from excessive combustion temperatures, and particulate matter (mostly soot).

Exhaust gas temperature

Exhaust gas temperature (EGT) is important to the functioning of the catalytic converter of an internal combustion engine. It may be measured by an exhaust gas temperature gauge. EGT is also a measure of engine health in gas-turbine engines (see below).

Cold engines

Steam from tailpipe of cold car

During the first two minutes after starting the engine of a car that has not been operated for several hours, the amount of emissions can be very high. This occurs for two main reasons:

Passenger car emissions summary

U.S. Environmental Protection Agency estimates of average passenger car emissions in the United States for April 2000[5]
Component Emission Rate Annual pollution emitted
Hydrocarbons 2.80 grams/mile (1.75 g/km) 77.1 pounds (35.0 kg)
Carbon monoxide 20.9 grams/mile (13.06 g/km) 575 pounds (261 kg)
NOx 1.39 grams/mile (0.87 g/km) 38.2 pounds (17.3 kg)
Carbon dioxide - greenhouse gas 415 grams/mile (258 g/km) 11,450 pounds (5,190 kg)

Comparable with the European emission standards EURO III as it was applied on October 2000

In 2000, the United States Environmental Protection Agency began to implement more stringent emissions standards for light duty vehicles. The requirements were phased in beginning with 2004 vehicles and all new cars and light trucks were required to meet the updated standards by the end of 2007.

United States Light-Duty Vehicle, Light-Duty Truck, and Medium-Duty Passenger Vehicle—Tier 2 Exhaust Emission Standards (for Bin 5)[6]
Component Emission Rate Annual pollution emitted
NMOG (Volatile organic compounds) 0.075  grams/mile (0.046 g/km) 2.1 pounds (0.95 kg)
Carbon Monoxide 3.4 grams/mile (2.1 g/km) 94 pounds (43 kg)
NOX 0.05 grams/mile (0.0305 g/km) 1.4 pounds (0.64 kg)
Formaldehyde 0.015 grams/mile (0.0092 g/km) 0.41 pounds (0.19 kg)

Types

Internal-combustion engines

Spark-ignition engines

In spark-ignition engines the gases resulting from combustion of the fuel and air mix are called exhaust gases. The composition varies from petrol to diesel engines, but is around these levels:

Combustion-engine exhaust gases[7]
All figures are approximate
% of total
Compound Petrol Diesel
nitrogen 71 67
carbon dioxide 14 12
water vapor 13 11
oxygen 10
Trace elements < 0.6 ~ 0.3
nitrogen oxides < 0.25 < 0.15
carbon monoxide 1 - 2 < 0.045
particulate matter < 0.045
hydrocarbons < 0.25 < 0.03
sulphur dioxide possible traces < 0.03

The 10% oxygen for "diesel" is likely if the engine was idling, e.g. in a test rig. It is much less if the engine is running under load.

Nitromethane additive

Exhaust gas from an internal combustion engine whose fuel includes nitromethane will contain nitric acid vapour, which is corrosive, and when inhaled causes a muscular reaction making it impossible to breathe. People exposed to it should wear a gas mask.[8]

Diesel engines

See Diesel exhaust; Soot.

Gas-turbine engines

Jet engines and rocket engines

What looks like exhaust from jet engines, is actually contrail. (Jet flying over the United States Air Force Academy in Colorado Springs, Colorado).

In jet engines and rocket engines, exhaust from propelling nozzles which in some applications shows shock diamonds.

Other types

From burning coal

Steam engines

In steam engine terminology the exhaust is steam that is now so low in pressure that it can no longer do useful work.

Main motor vehicle emissions

NOx

Smog in New York City as viewed from the World Trade Center in 1988.

Mono-nitrogen oxides NO and NO2 (whether produced this way or naturally by lightning) react with ammonia, moisture, and other compounds to form nitric acid vapor and related particles. Small particles can penetrate deeply into sensitive lung tissue and damage it, causing premature death in extreme cases. Inhalation of such particles may cause or worsen respiratory diseases such as emphysema and bronchitis. It may also aggravate existing heart disease.[9][10][11] In a 2005 U.S. EPA study the largest emissions of NOx came from on road motor vehicles, with the second largest contributor being non-road equipment which is mostly gasoline and diesel stations.[11]

The resulting nitric acid may be washed into soil, where it becomes nitrate, which is useful to growing plants.

Volatile organic compounds

Non-road equipment is mostly gasoline and diesel stations.[12]

When oxides of nitrogen (NOx) and volatile organic compounds (VOCs) react in the presence of sunlight, ground level ozone is formed, a primary ingredient in smog. A 2005 U.S. EPA report gives road vehicles as the second largest source of VOCs in the U.S. at 26% and 19% are from non road equipment which is mostly gasoline and diesel stations.[12] 27% of VOC emissions are from solvents which are used in the manufacturer of paints and paint thinners and other uses.[13]

Ozone

Ozone is beneficial in the upper atmosphere,[14] but at ground level, ozone irritates the respiratory system, causing coughing, choking, and reduced lung capacity.[15] It also has many bad effects throughout the ecosystem.[16]

Carbon monoxide (CO)

MOPITT satellite computer image of carbon monoxide March 2010.

Carbon monoxide poisoning is the most common type of fatal air poisoning in many countries.[17] Carbon monoxide is colorless, odorless and tasteless, but highly toxic. It combines with hemoglobin to produce carboxyhemoglobin, which is ineffective for delivering oxygen to bodily tissues. In 2011, 52% of carbon monoxide emissions were created by mobile vehicles in the U.S.[18]

Hazardous air pollutants (toxics)

Chronic (long-term) exposure to benzene (C6H6) damages bone marrow. It can also cause excessive bleeding and depress the immune system, increasing the chance of infection. Benzene causes leukemia and is associated with other blood cancers and pre-cancers of the blood.[19][20]

Particulate matter (PM10 and PM2.5)

The health effects of inhaling airborne particulate matter have been widely studied in humans and animals and include asthma, lung cancer, cardiovascular issues, and premature death. Because of the size of the particles, they can penetrate the deepest part of the lungs.[21] A 2011 UK study estimates 90 deaths per year due to passenger vehicle PM.[22] In a 2006 publication, the U.S. Federal Highway Administration (FHWA) state that in 2002 about 1 per-cent of all PM10 and 2 per-cent of all PM2.5 emissions came from the exhaust of on-road motor vehicles (mostly from diesel engines).[23]

Carbon dioxide (CO2)

Carbon dioxide is a greenhouse gas. Motor vehicle CO2 emissions are part of the anthropogenic contribution to the growth of CO2 concentrations in the atmosphere which some claim is causing climate change.[24] Motor vehicles are calculated to generate about 20% of the European Union's man-made CO2 emissions, with passenger cars contributing about 12%.[25] European emission standards limit the CO2 emissions of new passenger cars and light vehicles. The European Union average new car CO2 emissions figure dropped by 5.4% in the year to the first quarter of 2010, down to 145.6 g/km.[26]

Water vapor

Vehicle exhaust contains much water vapor.

Water recovery

There has been research into ways that troops in deserts can recover drinkable water from their vehicles' exhaust gases. [27]

Pollution reduction

Emission standards focus on reducing pollutants contained in the exhaust gases from vehicles as well as from industrial flue gas stacks and other air pollution exhaust sources in various large-scale industrial facilities such as petroleum refineries, natural gas processing plants, petrochemical plants and chemical production plants.[28][29] However, these are often referred to as flue gases. Catalytic converters in cars intend to break down the pollution of exhaust gases using a catalyst. Scrubbers in ships intend to remove the sulfur dioxide (SO2) of marine exhaust gases. The regulations on marine sulfur dioxide emissions are tightening, however only a small number of special areas worldwide have been designated for low sulfur diesel fuel use only.

One of the advantages claimed for advanced steam technology engines is that they produce smaller quantities of toxic pollutants (e.g. oxides of nitrogen) than petrol and diesel engines of the same power. They produce larger quantities of carbon dioxide but less carbon monoxide due to more efficient combustion.

Health studies

Researchers from the University of California, Los Angeles School of Public Health say preliminary results of their statistical study of children listed in the California Cancer Registry born between 1998 and 2007 found that traffic pollution may be associated with a 5% to 15% increase in the likelihood of some cancers.[30] A World Health Organization study found that diesel fumes cause an increase in lung cancer.[31]

Localised effects

The California Air Resources Board (C.A.R.B.) found in studies that 50% or more of the air pollution (smog) in Southern California is due to car emissions.

See also

Automobile exhaust

References

  1. Omidvarborna; et al. "Characterization of particulate matter emitted from transit buses fueled with B20 in idle modes". Journal of Environmental Chemical Engineering. 2 (4): 2335–2342. doi:10.1016/j.jece.2014.09.020.
  2. Caiazzo, Fabio; Ashok, Akshay; Waitz, Ian A.; Yim, Steve H.L.; Barrett, Steven R.H. (November 2013). "Air pollution and early deaths in the United States. Part I: Quantifying the impact of major sectors in 2005". Atmospheric Environment. Elsevier. 79: 198–208. Bibcode:2013AtmEn..79..198C. doi:10.1016/j.atmosenv.2013.05.081. Retrieved 25 October 2013.
  3. Roland Pease. "Traffic pollution kills 5,000 a year in UK, says study". BBC News.
  4. Pulkrabek W.W. (2004) Engineering Fundamentals of the Internal Combustion Engine. Pearson Prentice Hall, new Jersey
  5. "Average Annual Emissions and Fuel Consumption for Passenger Cars and Light Trucks" (PDF). Transportation and Air Quality. United States Environmental Protection Agency.
  6. "Light-Duty Vehicle, Light-Duty Truck, and Medium-Duty Passenger Vehicle -- Tier 2 Exhaust Emission Standards". Emission Standards Reference Guide. United States Environmental Protection Agency. 14 November 2012.
  7. Self-Study Programme 230: Motor Vehicle Exhaust Emissions (PDF). AUDI. April 2000. Retrieved 23 March 2012.
  8. turbofast.com
  9. "Health". Nitrogen Dioxide. United States Environmental Protection Agency. 14 February 2013.
  10. "The Regional Transport of Ozone: New EPA Rulemaking on Nitrogen Oxide Emissions (EPA-456/F-98-006)" (PDF). United States Environmental Protection Agency. September 1998.
  11. 1 2 "State and County Emission Summaries: Nitrogen Oxides". Air emission sources. United States Environmental Protection Agency. 25 October 2013.
  12. 1 2 "State and County Emission Summaries: Volatile Organic Compounds". Air emission sources. United States Environmental Protection Agency. 25 October 2013.
  13. "Volatile Organic Compounds (VOCs)". Toxic Substances Hydrology Program. United States Geological Survey (USGS). 12 April 2013.
  14. http://www.epa.gov/ozone/basicinfo.html
  15. http://www.epa.gov/airquality/ozonepollution/health.html
  16. http://www.epa.gov/groundlevelozone/ecosystem.html
  17. Omaye ST. (2002). "Metabolic modulation of carbon monoxide toxicity". Toxicology. 180 (2): 139–150. doi:10.1016/S0300-483X(02)00387-6. PMID 12324190.
  18. "State and County Emission Summaries: Carbon Monoxide". Air Emission Sources. United States Environmental Protection Agency. 25 October 2013.
  19. "Exhaust emissions: What comes out of your car's exhaust?". Automobile Association Developments Limited. 23 February 2012.
  20. "Air Toxics from Motor Vehicles" (PDF). Transportation and Air Quality. United States Environmental Protection Agency.
  21. Region 4: Laboratory and Field Operations — PM 2.5 (2008).PM 2.5 Objectives and History. U.S. Environmental Protection Agency.
  22. Mazzi, Eric A.; Dowlatabadi, Hadi (2007). "Air Quality Impacts of Climate Mitigation: UK Policy and Passenger Vehicle Choice". Environmental Science & Technology. 41 (2): 387. doi:10.1021/es060517w.
  23. "Transportation Air Quality: Selected Facts and Figures". U.S. Department of Transportation Federal Highway Commission. 2006. Retrieved 2010-04-14.
  24. IPCC, 2013: Summary for Policymakers. In: Climate Change 2013: The Physical Science Basis. Contribution of Working Group I to the Fifth Assessment Report of the Intergovernmental Panel on Climate Change [Stocker, T.F., D. Qin, G.-K. Plattner, M. Tignor, S.K. Allen, J. Boschung, A. Nauels, Y. Xia, V. Bex and P.M. Midgley (eds.)]. Cambridge University Press, Cambridge, United Kingdom and New York, NY, USA.|http://www.ipcc.ch/pdf/assessment-report/ar5/wg1/WG1AR5_SPM_FINAL.pdf
  25. "Commission plans legislative framework to ensure the EU meets its target for cutting CO2 emissions from cars". European Commission. 2007-02-07.
  26. "EU Average New Car CO2 Emissions Down 5.4 Percent in Q1". autoevolution. SoftNews NET. 2010-04-19.
  27. Google search
  28. EPA Plain English Guide to the Clean Air Act
  29. US EPA Publication AP 42, Fifth Edition, Compilation of Air Pollutant Emission Factors
  30. Reinberg, Steven (9 April 2013). "Smog Exposure During Pregnancy Might Raise Child's Cancer Risk: Study". USNews.
  31. http://www.iarc.fr/en/media-centre/pr/2012/pdfs/pr213_E.pdf

External links

This article is issued from Wikipedia - version of the 11/11/2016. The text is available under the Creative Commons Attribution/Share Alike but additional terms may apply for the media files.