Lightweight Medium Machine Gun

The Lightweight Medium Machine Gun (LWMMG) is a prototype machine gun being developed by General Dynamics.

Design

The LWMMG is designed to fill the gap between 7.62 mm and .50 BMG machine guns. The weapon uses the .338 Norma Magnum round, giving it greater lethality and double the range of the 7.62 NATO round. The LWMMG has a rate of fire of 500 rounds per minute, an effective range of 1,700 meters (1,860 yards), and a maximum range of 5,642 meters (6,170 yards). It weighs 24 pounds, making it only slightly heavier than the M240L, and 3 lb (1.4 kg) lighter than the M240B. The .338NM bullet has over 6,300 J (4,600 ft·lb) of muzzle energy and is four times more powerful than the 7.62 NATO at 1,000 meters. An individual round is twice as heavy (45.5 grams compared to 24 grams), as are each belt link (8 grams compared to 4 grams). For each weapon to fire for one minute, a belt of 500 .338NM rounds would weigh 37.6 kg (83 lb), while a belt of 800 7.62 NATO rounds would weigh 34.4 kg (76 lb). The LWMMG is operated by a gas-operated, long-stroke piston with a rotating bolt located under the barrel and fires from an open bolt. It uses “Short Recoil Impulse Averaging” technology, patented by General Dynamics and previously used on their XM806 machine gun, where the entire barrel, barrel extension, gas system, and bolt assembly recoil inside the outer housing. The LWMMG is equipped with a quick-change barrel, quad picatinny rails, collapsable stock, and can be used by dismounted troops or mounted on a platform.^[1][2][3]

The LWMMG is pitched as being a bridge between 7.62 NATO and .50 BMG machine guns. While the M240 has an effective range of 1,100 m, the LWMMG fires a 300 gr (19 g) .338 bullet that can provide effective and accurate fire out to 1,700 m. General Dynamics officials say their machine gun is not meant to be a replacement for the M240, but to give the ability to put effective fire on targets at extended ranges. 100 rounds of 7.62 NATO weighs 7 lb (3.2 kg), while a 100 round box of .338 Norma Magnum weighs 9 lb (4.1 kg). The LWMMG can be mounted on an M240 mount and costs about the same. While the company is satisfied with the shorter .338NM cartridge's performance, the gun could easily be converted to .338 Lapua Magnum. The gun's short recoil operating system causes the barrel to reciprocate, similar to the M2 machine gun. This combined with a gas system to minimize recoil balances positive and negative recoil forces, allowing a gunner to fire a round with significantly greater energy but with the recoil profile similar to a 7.62 mm round from an M240.^[4]

History

General Dynamics first realized the capability gap being experienced by U.S. forces in Afghanistan around 2010. In many cases, troops were on low ground and being engaged by PKM machine gun fire from the high ground, forcing them to return fire from where they were instead of being able to seek a better position. The M2 .50-caliber machine gun is too heavy for use by dismounted patrols, and rounds from an M240 begin to drift off target at 800 meters, especially when shooting upwards. At closer ranges, an M240 is accurate but does not have enough penetrating power against hard structures. The Precision Sniper Rifle competition going on at that time also showed the U.S. military was interested in infantry weapons with a 1,500-meter range. To achieve desired range capabilities, the .338-caliber was chosen, specifically the .338 Norma Magnum over the .338 Lapua Magnum for several reasons including greater barrel life and a less tapered case for better use in a belt link. At 1,000 yd (914 m), the 7.62 NATO's velocity drops to about 1,000 ft/s (300 m/s); at that range, the .338NM travels at 2,000 ft/s (610 m/s) and out to 1,100 yd (1,006 m), the round is capable of defeating Level III armor. A machine gun was then designed around the concept with Short Recoil Impulse Averaging technology, uses available subsystem components to keep cost down, and has a broad view 6-power scope to enable point target engagement out to 1,000-1,200 meters. Development of prototypes was entirely company-funded and took 12 months. The LWMMG was first unveiled on 15 May 2012 at the Joint Armaments Conference in Seattle, Washington.^[5][6]

An improved LWMMG was displayed at AUSA 2014 with its weight decreased to 22 lb (10.0 kg). Previously, the gun underwent a firing demonstration with special operations elements at Camp Roberts, California. When firing from a bipod, the gunners were able to fire directly and hit targets as far out as 1,950 m (2,133 yd). At that range, a .50 caliber machine gun is designed to be an area weapon and could only fire accurately with single shots, while the LWMMG can maintain accurate automatic fire beyond what the .50 Cal is capable of. This showed the weapon's significance of hitting targets at longer ranges than what an M240 can do that would require the use of a vehicle-mounted .50 caliber weapon. A demonstration firing of the LWMMG is expected to take place in late October at Fort Benning, Georgia.^[7]

References

1. ↑ General Dynamics Unveils New Medium-caliber Machine Gun at Joint Armaments Conference in Seattle - General Dynamics Press Release, 15 May 2012
2. ↑ .338 NM Lightweight Medium Machine Gun (LWMMG) - Thefirearmblog.com, 16 May 2012
3. ↑ GD Lightweight Medium Machine Gun / LWMMG - World.Guns.ru
4. ↑ GD Shows Off Long-Range Machine Gun - Kitup.Military.com, 25 September 2013
5. ↑ General Dynamics’ New General Purpose Machine Gun in .338 Norma Magnum Effective to 1800 Yards - Guns.com, 16 May 2012
6. ↑ Revolutionary Lightweight Machine Gun Prototype Unveiled by GDATP - Defensemedianetwork.com, 24 May 2012
7. ↑ GD-OTS refines medium machine gun design - Shephardmedia.com, 15 October 2014

External links

• LWMMG factsheet - General Dynamics
• A new machine gun-the right weapon for today's environment
• .338 Medium Machine Gun Suppressor Test Results
• "Distinct Overmatch on the Current and Future Battlefield"
• General Dynamics Ordnance & Tactical Systems .338 Machine Gun