Sucralose

Sucralose[1]
Names
IUPAC name
(1→6)-Dichloro-(1→6)-dideoxy-β-D-fructofuranosyl-4-chloro-4-deoxy-α-D-galactopyranoside
Systematic IUPAC name
(2R,3R,4R,5R,6R)-2-[(2R,3S,4S,5S)-2,5-Bis(chloromethyl)-3,4-dihydroxyoxolan-2-yl]oxy-5-chloro-6-(hydroxymethyl)oxane-3,4-diol[2]
Other names
1',4,6'-Trichlorogalactosucrose; Trichlorosucrose; E955; 4,1',6'-Trichloro-4,1',6'-trideoxygalactosucrose; TGS; Splenda[3]
Identifiers
56038-13-2 YesY
3D model (Jmol) Interactive image
ChEBI CHEBI:32159 YesY
ChemSpider 64561 YesY
ECHA InfoCard 100.054.484
EC Number 259-952-2
E number E955 (glazing agents, ...)
KEGG C12285 YesY
PubChem 71485
UNII 96K6UQ3ZD4 YesY
Properties
C12H19Cl3O8
Molar mass 397.64 g/mol
Appearance Off-white to white powder
Odor Odorless
Density 1.69 g/cm3
Melting point 125 °C (257 °F; 398 K)
283 g/L (20°C)
Acidity (pKa) 12.52±0.70
Hazards
NFPA 704
Flammability code 1: Must be pre-heated before ignition can occur. Flash point over 93 °C (200 °F). E.g., canola oil Health code 1: Exposure would cause irritation but only minor residual injury. E.g., turpentine Reactivity code 0: Normally stable, even under fire exposure conditions, and is not reactive with water. E.g., liquid nitrogen Special hazards (white): no codeNFPA 704 four-colored diamond
1
1
0
Except where otherwise noted, data are given for materials in their standard state (at 25 °C [77 °F], 100 kPa).
YesY verify (what is YesYN ?)
Infobox references
Comparison of the chemical structures of sucrose (top) and sucralose (bottom)

Sucralose is an artificial sweetener and sugar substitute. The majority of ingested sucralose is not broken down by the body, so it is noncaloric.[4] In the European Union, it is also known under the E number E955. Sucralose is about 320 to 1,000 times sweeter than sucrose,[5] three times as sweet as aspartame and twice as sweet as saccharin and three times as sweet as acesulfame potassium. It is stable under heat and over a broad range of pH conditions. Therefore, it can be used in baking or in products that require a longer shelf life. The commercial success of sucralose-based products stems from its favorable comparison to other low-calorie sweeteners in terms of taste, stability, and safety.[6] Common brand names of sucralose-based sweeteners are Splenda, Zerocal, Sukrana, SucraPlus, Candys, Cukren, and Nevella. Canderel Yellow also contains Sucralose, but the original Canderel and Green Canderel do not.

History

Sucralose was discovered in 1976 by scientists from Tate & Lyle, working with researchers Leslie Hough and Shashikant Phadnis at Queen Elizabeth College (now part of King's College London). While researching ways to use sucrose and its synthetic derivatives for industrial use, Phadnis was told to "test" a chlorinated sugar compound. Phadnis thought Hough asked him to "taste" it, so he did.[7] He found the compound to be exceptionally sweet.

Tate & Lyle patented the substance in 1976; as of 2008, the only remaining patents concern specific manufacturing processes.[8]

Sucralose was first approved for use in Canada in 1991. Subsequent approvals came in Australia in 1993, in New Zealand in 1996, in the United States in 1998, and in the European Union in 2004. By 2008, it had been approved in over 80 countries, including Mexico, Brazil, China, India, and Japan.[9] In 2006, the US Food and Drug Administration amended the regulations for foods to include sucralose as a "non-nutritive sweetener" in food.[10] In May 2008, Fusion Nutraceuticals launched a generic product to the market, using Tate & Lyle patents.

In April 2015 PepsiCo announced that it would be moving from aspartame to sucralose for most of its diet drinks in the US,[11] due to sales of Diet Pepsi falling by more than 5% in the US. PepsiCo says its decision is a commercial one - responding to consumer preferences.

Production

Sucralose is manufactured by the selective chlorination of sucrose in a multistep synthesis, which substitutes three of the hydroxyl groups of sucrose with chlorine atoms. This chlorination is achieved by selective protection of a primary alcohol group, followed by chlorination of the partially acetylated sugar with excess chlorinating agent, and then by removal of the acetyl groups to give the desired sucralose product.[12][13] A company realignment announced April 21, 2015 moved sucralose production from Tate & Lyle's plant on Jurong Island, Singapore to the recently reopened plant in McIntosh, Alabama.[14]

Product uses

Sucralose is found in many food and beverage products, used because it is a no-calorie sweetener, does not promote dental cavities,[15] is as safe for consumption by diabetics and nondiabetics,[16][17] and does not affect insulin levels.[18] Sucralose is used as a replacement for, or in combination with, other artificial or natural sweeteners such as aspartame, acesulfame potassium or high-fructose corn syrup. Sucralose is used in products such as candy, breakfast bars and soft drinks. It is also used in canned fruits wherein water and sucralose take the place of much higher calorie corn syrup-based additives. Sucralose mixed with maltodextrin or dextrose (both made from corn) as bulking agents is sold internationally by McNeil Nutritionals under the Splenda brand name. In the United States and Canada, this blend is increasingly found in restaurants, in yellow packets, in contrast to the blue packets commonly used by aspartame and the pink packets used by those containing saccharin sweeteners; in Canada, though, yellow packets are also associated with the SugarTwin brand of cyclamate sweetener.

Cooking

Sucralose is a highly heat-stable noncaloric sweetener, allowing it to be used in many recipes with little or no sugar. It is available in a granulated form that allows for same-volume substitution with sugar. This mix of granulated sucralose includes fillers, all of which rapidly dissolve in liquids. While the granulated sucralose provides apparent volume-for-volume sweetness, the texture in baked products may be noticeably different. Sucralose is not hygroscopic, which can lead to baked goods that are noticeably drier and manifest a less dense texture than those made with sucrose. Unlike sucrose, which melts when baked at high temperatures, sucralose maintains its granular structure when subjected to dry, high heat (e.g., in a 350 °F or 180 °C oven). Furthermore, in its pure state, sucralose begins to decompose at 119 °C or 246 °F.[19] Thus, in some baking recipes, such as crème brûlée, which require sugar sprinkled on top to partially or fully melt and crystallize, substituting sucralose will not result in the same surface texture, crispness, or crystalline structure.

Packaging and storage

Pure sucralose is sold in bulk, but not in quantities suitable for individual use, although some highly concentrated sucralose–water blends are available online. These concentrates contain one part sucralose for each two parts water. A quarter teaspoon of concentrate substitutes for one cup of sugar. Pure, dry sucralose undergoes some decomposition at elevated temperatures. In solution or blended with maltodextrin, it is slightly more stable. Most products containing sucralose add fillers and additional sweetener to bring the product to the approximate volume and texture of an equivalent amount of sugar.

Effect on caloric content

Though sucralose contains no calories, products that contain fillers, such as maltodextrin and/or dextrose, add about 2–4 calories per teaspoon or individual packet, depending on the product, the fillers used, brand, and the intended use of the product.[20] The US Food and Drug Administration (FDA) allows for any product containing fewer than five calories per serving to be labeled as "zero calories".[21]

Health, safety, and regulation

Sucralose has been accepted as safe by several national and international food safety regulatory bodies, including the FDA, The Joint FAO/WHO Expert Committee Report on Food Additives, the European Union's Scientific Committee on Food, Health Protection Branch of Health and Welfare Canada, and Food Standards Australia New Zealand. According to the Canadian Diabetes Association, the amount of sucralose that can be consumed over a person's lifetime without any adverse effects is 9 mg per kg of body weight per day.[22][23]

"In determining the safety of sucralose, the FDA reviewed data from more than 110 studies in humans and animals. Many of the studies were designed to identify possible toxic effects, including carcinogenic, reproductive, and neurological effects. No such effects were found, and FDA's approval is based on the finding that sucralose is safe for human consumption." For example, McNeil Nutritional LLC studies submitted as part of its U.S. FDA Food Additive Petition 7A3987 indicated that "in the 2-year rodent bioassays ... there was no evidence of carcinogenic activity for either sucralose or its hydrolysis products ..."[24]

Safety of consumption

Results from over a hundred animal and clinical studies in the FDA approval process unanimously indicated a lack of risk associated with sucralose consumption.[25][26][27][28] When the estimated daily intake (EDI) is compared to the intake at which adverse effects are seen (known as the highest no adverse effects limit, or HNEL) at 1500 mg/kg BW/day,[29] a large margin of safety exists. The bulk of sucralose ingested is not absorbed by the gastrointestinal (GI) tract and is directly excreted in the feces, while 11–27% of it is absorbed.[5] The amount absorbed from the GI tract is largely removed from the blood stream by the kidneys and eliminated in the urine, with 20–30% of the absorbed sucralose being metabolized.[5] This means that only between 2–8% of sucralose consumed is metabolized, on average.

Potential effects on health

Despite being generally recognized as safe by regulatory agencies based on information from a multitude of large-scale and clinical studies, sucralose has been the subject of a few small-scale or animal studies attempting to determine yet-unknown effects on illnesses such as obesity, diabetes, and cancer.

A Duke University animal study funded by the Sugar Association[30] found evidence that doses of Splenda between 100 and 1000 mg/kg BW/day, containing sucralose at 1.1 to 11 mg/kg BW/day, fed to rats reduced fecal microflora, increased the pH level in the intestines, contributed to increases in body weight, and increased levels of P-glycoprotein (P-gp).[31] These effects have not been reported in humans.[5] An expert panel, including scientists from Duke University, Rutgers University, New York Medical College, Harvard School of Public Health, and Columbia University reported in Regulatory Toxicology and Pharmacology that the Duke study was "not scientifically rigorous and is deficient in several critical areas that preclude reliable interpretation of the study results".[32]

The Center for Science in the Public Interest, a consumer advocacy group for food products, downgraded sucralose from "Safe" to "Caution" in June 2013, citing an unpublished study linking sucralose consumption with leukemia risk in rats.[33] The study has been criticized as being poorly executed and reported.[34] The study was finally published on January 29 in the peer-reviewed International Journal of Occupational and Environmental Health.[35] One study linked large doses of sucralose, equivalent to 11,450 packets (136 g) per day in a person (i.e., ~360 times the ADI of 5 mg/kg BW/day), to DNA damage in mice.[36] Sucralose has not shown any DNA-damaging properties in DNA repair assays at normal consumption levels, and no evidence of carcinogenicity.[37]

In a small-scale study of 17 obese test subjects, sucralose was found to affect glycemic and insulin responses, leading to an increase in peak plasma glucose concentration and insulin secretion rate.[38] In a 2014 study, sucralose limited the growth of Bacteroides bacteria in vitro.[39]

Environmental effects

According to one study, sucralose is digestible by a number of microorganisms and is broken down once released into the environment.[40] However, measurements by the Swedish Environmental Research Institute have shown sewage treatment has little effect on sucralose, which is present in wastewater effluents at levels of several μg/l (ppb).[41] No ecotoxicological effects are known at such levels, but the Swedish Environmental Protection Agency warns a continuous increase in levels may occur if the compound is only slowly degraded in nature. When heated to very high temperatures (over 350 °C or 662 °F) in metal containers, sucralose can produce in the resulting smoke polychlorinated dibenzo-p-dioxins and other persistent organic pollutants.[42]

Sucralose has been detected in natural waters. Studies indicate that this has virtually no impact on the early life development of certain animal species.[43]

Further reading

See also

Wikimedia Commons has media related to Sucralose.

References

  1. ↑ Merck Index, 11th Edition, 8854.
  2. ↑ "sucralose 56038-13-2". The Good Scents Company Information System. Retrieved 30 January 2014.
  3. ↑ Anonymous. Scifinder – Substance Detail for 56038-13-2, October 30, 2010.
  4. ↑ "Gestational Diabetes and Low-Calorie Sweeteners: Answers to Common Questions" (PDF). Food Insight. Retrieved 15 May 2015.
  5. 1 2 3 4 Michael A. Friedman, Lead Deputy Commissioner for the FDA, Food Additives Permitted for Direct Addition to Food for Human Consumption; Sucralose Federal Register: 21 CFR Part 172, Docket No. 87F-0086, April 3, 1998
  6. ↑ A Report on Sucralose from the Food Sanitation Council, The Japan Food Chemical Research Foundation
  7. ↑ Gratzer, Walter (28 November 2002). "5. Light on sweetness: the discovery of aspartame". Eurekas and Euphorias: The Oxford Book of Scientific Anecdotes. Oxford University Press. pp. 32–. ISBN 978-0-19-280403-7. Retrieved 1 August 2012.
  8. ↑ "Tate & Lyle loses sucralose patent case". ap-foodtechnology.com.
  9. ↑ "SPLENDA® Brand Sweetener FAQ: Safety & Product Information: What research has been conducted to confirm the safety of SPLENDA®". McNeil Nutritionals, LLC. Retrieved 2015-08-29.
  10. ↑ Turner, James (April 3, 2006). "FDA amends regulations that include sucralose as a non-nutritive sweetener in food." (PDF). FDA Consumer. Retrieved September 7, 2007.
  11. ↑
  12. ↑ Bert Fraser-Reid, 2012, "From Sugar to Splenda: A Personal and Scientific Journey of a Carbohydrate Chemist and Expert Witness," Berlin:Springer, pp. 199-210, and passim, see , accessed 2 November 2014.
  13. ↑ U.S. Patent 5,498,709
  14. ↑ "Food Business News". www.foodbusinessnews.net. Retrieved 2016-04-06.
  15. ↑ Food and Drug Administration (2006). "Food labeling: health claims; dietary noncariogenic carbohydrate sweeteners and dental caries.". Federal Register. 71 (60): 15559–15564. PMID 16572525.
  16. ↑ Grotz, VL; Henry, RR; McGill, JB; Prince, MJ; Shamoon, H; Trout, JR; Pi-Sunyer, FX (2003). "Lack of effect of sucralose on glucose homeostasis in subjects with type 2 diabetes". Journal of the American Dietetic Association. 103 (12): 1607–12. doi:10.1016/j.jada.2003.09.021. PMID 14647086.
  17. ↑ FAP 7A3987, August 16, 1996. pp. 1–357. A 12-week study of the effect of sucralose on glucose homeostasis and HbA1c in normal healthy volunteers, Center for Food Safety and Applied Nutrition, U.S. FDA
  18. ↑ Ford, HE; Peters, V; Martin, NM; Sleeth, ML; Ghatei, MA; Frost, GS; Bloom, SR (April 2011). "Effects of oral ingestion of sucralose on gut hormone response and appetite in healthy normal-weight subjects". European journal of clinical nutrition. 65 (4): 508–13. doi:10.1038/ejcn.2010.291. PMID 21245879.
  19. ↑ Bannach, Gilbert; Rafael R. Almeida; Luis. G. Lacerda; Egon Schnitzler; Massao Ionashiro (December 2009). "Thermal stability and thermal decomposition of sucralose". Sci. Rep. 34 (4): 21–26. doi:10.1590/S0100-46702009000400002.
  20. ↑ Filipic, Martha Chow Line: Sucralose sweet for calorie-counters (for 10/3/04) Ohio State Human Nutrition article on sucralose
  21. ↑ "CFR – Code of Federal Regulations Title 21". U.S. Food and Drug Administration. 2011-04-01. Retrieved 11 March 2012.
  22. ↑ "Canadian Diabetes Association 2008 Clinical Practice Guidelines for the Prevention and Management of Diabetes in Canada" (PDF). Canadian Journal of Diabetes. Canadian Diabetes Association. 32 (Supplement 1): S41. September 2008.
  23. ↑ Goldsmith LA (2000). "Acute and subchronic toxicity of sucralose". Food Chem Toxicol. 38 Suppl 2: S53–69. doi:10.1016/s0278-6915(00)00028-4. PMID 10882818.
  24. ↑ "Sucralose - FDA Final Rule - Food Additives Permitted for Direct Addition to Food for Human Consumption" (PDF). United States: Food and Drug Administration.
  25. ↑ Frank, Genevieve. "Sucralose: An Overview". Penn State University.
  26. ↑ Rodero, A. B.; Rodero, L. S.; Azoubel, R. (2009). "Toxicity of sucralose in humans: a review" (PDF). Int. J. Morphol. 27 (1): 239–244. doi:10.4067/s0717-95022009000100040.
  27. ↑ Grotz VL; Munro IC (2009). "An overview of the safety of sucralose". Regul Toxicol Pharmacol. 55 (1): 1–5. doi:10.1016/j.yrtph.2009.05.011. PMID 19464334.
  28. ↑ Grice HC; Goldsmith LA (2000). "Sucralose--an overview of the toxicity data". Food Chem Toxicol. 38 (Suppl 2): S1–6. doi:10.1016/S0278-6915(00)00023-5. PMID 10882813.
  29. ↑ Baird, I. M.; Shephard, N. W.; Merritt, R. J.; Hildick-Smith, G. (2000). "Repeated dose study of sucralose tolerance in human subjects". Food Chemical Toxicology. 38 (Supplement 2): S123–S129. doi:10.1016/S0278-6915(00)00035-1. PMID 10882825.
  30. ↑ Browning, Lynnley (2008-09-02). "New Salvo in Splenda Skirmish". The New York Times. Retrieved 2010-05-24.
  31. ↑ Abou-Donia, MB; El-Masry, EM; Abdel-Rahman, AA; McLendon, RE; Schiffman, SS (2008). "Splenda alters gut microflora and increases intestinal p-glycoprotein and cytochrome p-450 in male rats". J. Toxicol. Environ. Health Part A. 71 (21): 1415–29. doi:10.1080/15287390802328630. PMID 18800291.
  32. ↑ Daniells, Stephen (2009-09-02). "Sucralose safety 'scientifically sound': Expert panel".
  33. ↑ "CSPI Downgrades Splenda From "Safe" to "Caution"" (PDF). Center for Science in the Public Interest. June 12, 2013.
  34. ↑ "Controversial Italian Scientist Says Splenda Causes Cancer" (PDF). Forbes. April 2012.
  35. ↑ "CSPI Downgrades Sucralose From Caution To Avoid". CSPI. February 2016.
  36. ↑ Sasaki, YF; Kawaguchi, S; Kamaya, A; Ohshita, M; Kabasawa, K; Iwama, K; Taniguchi, K; Tsuda, S (2002-08-26). "The comet assay with 8 mouse organs: results with 39 currently used food additives". Mutation Research. 519 (1–2): 103–119. doi:10.1016/S1383-5718(02)00128-6. PMID 12160896.
  37. ↑ Weihrauch MR, Diehl V (2004). "Artificial sweeteners—do they bear a carcinogenic risk?". Ann Oncol. 15 (10): 1460–5. doi:10.1093/annonc/mdh256. PMID 15367404.
  38. ↑ Pepino, M. Y.; Tiemann, C. D.; Patterson, B. W.; Wice, B. M.; Klein, S. (2013). "Sucralose Affects Glycemic and Hormonal Responses to an Oral Glucose Load". Diabetes Care. 36 (9): 2530–5. doi:10.2337/dc12-2221. PMID 23633524.
  39. ↑ Rettig S, Tenewitz J, Ahearn G, Coughlin C (2014). "Sucralose causes a concentration dependent metabolic inhibition of the gut flora Bacteroides, B. fragilis and B. uniformis not observed in the Firmicutes, E. faecalis and C. sordellii (1118.1)". The FASEB Journal. 28 (1): Supplement 1118.1. ISSN 1530-6860. Retrieved 2016-04-16.
  40. ↑ Labare, Michael P; Alexander, Martin (1993). "Biodegradation of sucralose in samples of natural environments". Environmental Toxicology and Chemistry. 12 (5): 797–804. doi:10.1897/1552-8618(1993)12[797:BOSACC]2.0.CO;2.
  41. ↑ Measurements of Sucralose in the Swedish Screening Program 2007, Part I; Sucralose in surface waters and STP samples
  42. ↑ Dong, Shujun; Liu, Guorui; Hu, Jicheng; Zheng, Minghui (October 15, 2013). "Polychlorinated dibenzo-p-dioxins and dibenzofurans formed from sucralose at high temperatures". Scientific Reports. 3. doi:10.1038/srep02946.
  43. ↑ Stoddard KI, Huggett DB (2014). "Early Life Stage (ELS) Toxicity of Sucralose to Fathead Minnows, Pimephales promelas.". Bull Environ Contam Toxicol. 93 (4): 383–7. doi:10.1007/s00128-014-1348-9. PMID 25120258.

External links

Media related to Sucralose at Wikimedia Commons

This article is issued from Wikipedia - version of the 11/23/2016. The text is available under the Creative Commons Attribution/Share Alike but additional terms may apply for the media files.